Skip to main content

Originally published March 13, 2014 at 6:53 PM | Page modified March 13, 2014 at 8:22 PM

  • Share:
  • Comments (1)
  • Print

GM says ignition troubles surfaced during testing in 2001

GM filed new information with regulators that revealed the company’s first internal report on ignition-switch problems in small cars in 2001. Meanwhile a safety group says 303 died when air bags failed in two of the recalled models.

Bloomberg News

Most Popular Comments
Hide / Show comments
Media had non-stop hysterics in 2009 over Toyota accelerators, but ignored GM ignition... MORE


General Motors got its first internal report on ignition-switch problems in small cars in 2001, while developing the Saturn Ion, the automaker said in a letter to U.S. regulators.

GM thought it had fixed the ignition-switch defect, the carmaker said in a supplemental report filed with the National Highway Traffic Safety Administration (NHTSA) on Wednesday. Then in 2003, service technicians found that an owner with a heavy key ring was experiencing engine stalls while driving.

The flaw, linked to 12 deaths, led to the recall last month of 1.6 million cars.

Meanwhile, a new review of federal crash-data show that 303 people died after the air bags failed to deploy on two of the models that were recalled last month.

The review of the air-bag failures, by the Friedman Research Corp., adds to the mounting reports of problems that went unheeded before General Motors announced last month that it was recalling more than 1.6 million cars worldwide because of the defective switch.

GM has linked the deaths to the defective switch in the two models analyzed, the 2003-5 Chevrolet Cobalts and 2003-7 Saturn Ions, as well as four other models.

The Center for Auto Safety, a private watchdog group in Washington, D.C., commissioned the study, and, in a letter to the National Highway Traffic Safety Administration, criticized the agency for not detecting the air-bag failures, as well as the defective ignition switch.

Regulators said that there was still not enough evidence to warrant an investigation.

The company filed the new information with NHTSA on what it did to address the problem to better explain why it expanded the recall to six U.S. models from two, roughly doubling the number of cars covered, Greg Martin, a spokesman for Detroit-based GM, said in an email.

The details concern the company’s attempts to investigate ignition-switch issues in the Ion, the Saturn Sky, the Chevrolet HHR and the Pontiac Solstice.

“Today’s GM is fully committed to learning from the past while embracing the highest standards for quality and performance now and in the future,” Martin said.

GM later used the same part in the Chevrolet Cobalt and Pontiac G5.

The 2001 testing failure disclosed by GM is earlier than when the carmaker said it learned of flaws in the Cobalt.

Previously, the company said it had investigated in 2004 a consumer complaint and engineers were able to induce an engine stall. GM officials have said the problem was investigated at that time and no action was taken.

The flaw caused ignition switches to slip out of position and cut off engine power and deactivate air bags.

Meanwhile, NHTSA, the U.S. Transportation Department’s auto safety regulator, continued to come under criticism by lawmakers in Washington, D.C.

Sen. Patty Murray, D-Wash., chairman of the Transportation Appropriations Subcommittee, asked whether auto manufacturers take seriously existing laws that require early reporting, as well as the Transportation Department’s administration of them.

“It raises a lot of questions why it took almost a decade for the automaker to report a serious defect,” Murray said at a hearing with Transportation Secretary Anthony Foxx today.

Foxx reiterated comments acting NHTSA Administrator David Friedman said Wednesday, that more information from GM earlier in the process would have “changed the outcome.” Three crash investigations in cars that would later have been covered by the recall were inconclusive, he said.

“We will be very, very tough when we find timeliness has been a problem,” Foxx said.

The agency is still in the early stages of fact-finding in an inquiry into whether GM acted quickly enough once it was clear there was a safety-related defect.

The largest U.S. automaker said it knows of eight frontal-impact crashes and four deaths involving Ions that may be linked to the defect. It knows of three frontal crashes involving the HHR that may be related, which caused three injuries but no fatalities, it said.

“The difference between 10 or 12 years, if I’m a consumer, doesn’t make me feel any better or any worse, necessarily, about what happened,” Kelley Blue Book’s Gutierrez said of the evolving timeline. “What’s important for consumers at this point is what GM is doing to make it right.”

With assistance from Alan Ohnsman in Los Angeles and Laura Litvan in Washington, D.C.

Information from The New York Times is included in this report.

Four weeks for 99 cents of unlimited digital access to The Seattle Times. Try it now!

News where, when and how you want it

Email Icon

 Subscribe today!

Subscribe today!

99¢ for four weeks of unlimited digital access.



The Seattle Times

The door is closed, but it's not locked.

Take a minute to subscribe and continue to enjoy The Seattle Times for as little as 99 cents a week.

Subscription options ►

Already a subscriber?

We've got good news for you. Unlimited content access is included with most subscriptions.

Subscriber login ►